Kansas State University researchers are growing more than 300 cultivars of wheat in heat-controlled tents in order to test the effect of nighttime temperatures on the yield and quality of the crop. | Download this photo.
Crop scientists looking for ways to beat the heat
K-State builds first-ever facility to test effect of high nighttime temperatures on wheat
June 11, 2019
MANHATTAN, Kan. – Can a small circuit board, barely the size of a credit card, help the world’s wheat to beat the heat?
Kansas State University researchers think so, and they say that they’ve built the world’s first facility to help them prove it.
In a lush field north of the university’s Manhattan campus, the scientists are testing more than 300 wheat cultivars under heat-controlled tents to show that high nighttime temperatures are robbing the nation’s wheat growers of both the quantity and quality of their crop.
“A small computer, called a Raspberry Pi, is used to monitor temperature and adjust conditions inside the tents so that the researchers can determine the cultivars that are less – and more – susceptible to high temperatures,” said Dan Wagner, a graduate student in computer science who built the system.
“This is not just the wheat grown in Kansas,” said crop physiologist Krishna Jagadish, an associate professor of agronomy. “These lines represent the entire U.S. hard red winter wheat collection.”
Jagadish walks among eight sections of wheat, each split into 40 rows containing one wheat cultivar. It adds up to 320 wheat cultivars, many of the hard red winter wheat or their offshoots that are grown somewhere in the country.
The researchers have built six such tents, each growing the same 320 cultivars but held under different environmental conditions. There is no facility like this in the world, Jagadish said, noting that the project will provide researchers with precious data to help them generate newer wheat varieties with tolerance to heat.
“We will be harvesting each of the cultivars through the end of June,” said Raju Bheemanahalli, a post-doctoral fellow in K-State’s Department of Agronomy. “Then we will analyze the size and number of grains, protein content and more. From that, we will identify the genomic regions that will help in developing markers controlling heat tolerance.”
Eventually, he said, those markers can be used by wheat breeders to develop varieties that yield well even under more intense heat.
Regardless of where it’s grown, all wheat is susceptible to heat, and researchers now believe that high nighttime temperatures can be equally damaging as high daytime temperatures.
Controlling the test environment
The tents that K-State has built are designed to expose wheat to typical field conditions while comparing it closely to wheat grown under more controlled conditions.
“We have three control tents in which we don’t roll the side walls and end walls down so that we let fresh air in,” said Nathan Hein, an assistant scientist in K-State’s Department of Agronomy. “And then we have three heated tents that we completely shut down overnight.”
The heated tents are kept at a temperature 4 degrees Celsius above the outdoor temperature. Six sensors inside each tent are strategically located to make sure the temperature is held uniformly across the 320 wheat cultivars.
“The Pi (computer) operates like a thermostat in your house,” Hein said. “Once the temperature drops too low, it flips the relay and turns the heater on. When the tent’s temperature is 4 degrees Celsius above the outside temperature, then the Pi shuts the heaters down.”
Jagadish said that causing stress uniformly to the cultivars in a common setting provides valuable clues to which ones will perform better in actual field conditions.
“We may find that specific lines coming from a region are more susceptible to heat, and that the quality of the wheat gets even worse as nighttime temperatures increase,” he said.
The researchers have been studying the effect of nighttime temperatures for more than a year, first in a smaller pilot project and now in a more expanded, fully operational facility. Jagadish said it’s clear that high nighttime temperatures cause a deterioration in the wheat crop; the key is to minimize the damage.
“When exposed to high nighttime temperatures during grain filling, the grain weight, yield and starch content goes down, and the protein content increases,” Jagadish said.
“That changes the dynamics of what is required for maintaining the quality of bread, including the elasticity, and qualities like that. High level of protein with increasing nighttime temperature will make the bread crusty, which means that you may not get the loaf of bread as you really like it.”
Research has beer implications too
Jagadish said that much of Kansas State’s work in the past has been directed toward ensuring quality bread wheat, but his team’s current study also has some implications for another growing industry – craft beer.
Brewers prefer grains that are plump, but high nighttime temperatures tend to shrink the size of the grain. Jagadish said there are indications that smaller wheat grains will not only affect the quantity of beer but also the quality.
In addition, the concept of using tents to test heat stress on wheat can be applied to other farm crops, notably corn and sorghum. “This facility can be used for any crop,” Jagadish said. “That’s how it’s built.”
K-State’s work is funded for two more years by the National Science Foundation through its Established Program to Stimulate Competitive Research program, known as EPSCoR. K-State is working on the study in partnership with the University of Nebraska and Arkansas State University, which currently is looking to build its own heat tents.